EXPERIMENTAL VALIDATION OF MODELS FOR PREDICTING THE FORCES FOR REMOVING WAX DEPOSITS IN PIPELINES USING PIGS / AVALIAÇÃO DE MODELOS PARA A REMOÇÃO DE DEPÓSITOS DE PARAFINA EM DUTOS UTILIZANDO PIGS
AUTOR(ES)
ROBSON DE OLIVEIRA SOUZA
DATA DE PUBLICAÇÃO
2005
RESUMO
Pigging is still the most widely used method to remove wax deposits in subsea pipelines. The passage of a pig is still considered a risky operation, since the pressure gradient available for driving the pig might not be sufficient to overcome the contact forces between the pig and the wall, as well as the forces required to remove the wax deposit. If this is the case, the pig will be stuck, and costly remediation procedures will have to be implemented. In the present work, an experimental study was carried out aimed at collecting reliable data on the contact forces developed between pigs and the pipe wall for some types of pigs commonly used in field operations. Also, as part of the work, the forces required to remove wax deposits prepared under controlled conditions were recorded. To this end, a test section was specially designed and constructed. In the tests, the pigs were pulled through a set of pipes at constant speed by a winch, while the pulling force was continuously recorded by load cells. The results obtained for the contact forces between disc, foam and conical cup pigs and the pipe wall without wax deposits were compared with models available in the literature. Good level of agreement was obtained. Experimental results obtained for the cases where the test pipes had controlled wax deposits where compared with the only model available in the literature for predicting the forces required to break the wax deposits. The comparisons demonstrated that the measured forces required for breaking the wax deposit can be estimated by the available models within an uncertainty of ±30%.
ASSUNTO(S)
deposito removal mechanics flow assurance garantia de escoamento deposit remocao mecanica paraffin parafina
ACESSO AO ARTIGO
Documentos Relacionados
- AVALIAÇÃO DO MECANISMO DE DIFUSÃO MOLECULAR PARA A MODELAGEM DA DEPOSIÇÃO DE PARAFINA EM DUTOS DE PETRÓLEO
- THERMAL ANALYSIS OF WAX BLOCKAGES REMOVAL IN PETROLEUM SUBSEA PIPELINES BY INDUCTIVE HEATING
- ESTUDO SOBRE A DEPOSIÇÃO DE PARAFINA EM LINHAS DE PETRÓLEO
- WAX DEPOSITION STUDY IN A MULTIPHASE PIPE FLOW
- EVALUATION OF SLEEVE TYPE REPAIR MODELS FOR PIPELINES WITH THICKNESS LOSS DEFECTS